Volvo RWD 200 Forum

INDEX FOR 10/2025(CURRENT) INDEX FOR 10/2004 200 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE 

Transmission pan gasket issue 200

posted by  NewMexico240 on  Mon Jul 9 21:14 CST 2018
Author: [PROFILE] [EVERY POST] [THREADS] [BEST POSTS] RSS Feed     [IGNORE ALL POSTS]
last visit: Fri Oct 24 11:52 CST 2014
[RELATED]

Hi Phil,
I removed the tranny fluid pan again today and realized I had destroyed the rubber gasket. I had used gasket sealer and 44 inch pounds and it smashed the gasket to pieces. I went to get another at autozone and the same maker Fel-Pro and same box with same part number had a non-rubber gasket in it...go figure. I installed without gasket maker and only tightened the 14 bolts finger tight using the 10mm socket and an extension without using the the ratchet. Then added the ratchet for about a 1/5 turn on each bolt. Filled her with tranny fluid and she seems to be holding her fluid. I'll report back tomorrow after a drive.






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New Transmission pan gasket issue [200]
posted by  NewMexico240 subscriber  on Mon Jul 9 17:42 CST 2018 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.