Volvo RWD 200 Forum

INDEX FOR 10/2025(CURRENT) INDEX FOR 6/2008 200 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE Replies to this message will be emailed.    PRINT   SAVE 

Converting my 1983 242 TI to a manual (m46) 200 1983

I daresay there is a wire or two from the automatic OD setup that could be scavenged if you trace it--pull a schematic up in Bentley and see. That said, the OD setup is so simply, you should just wire it up yourself. Go with the earlier OD setup, the later one with the more complex relay is a pain.

Don't forget to insulate the edge of the shifter opening with a slit piece of hose where you cross it with the harness going to the OD switch. Same for the harness going down to the trans. By the way, you can overfill your trans by using the fourth gear switch port!

When we convert cars to manual trans, we use almost exclusively the nine inch clutch with the "dog dish" flywheel. It's smoother and lighter, and the smaller lighter drivers don't complain about it. Not that the 8.5" clutch is terribly heavy, but there is a noticeable difference. 9" is nicer in traffic for sure.

DS






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New Converting my 1983 242 TI to a manual (m46) [200][1983]
posted by  Mr brick driver  on Thu May 22 07:52 CST 2014 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.