Volvo AWD S80 Forum

INDEX FOR 1/2026(CURRENT) INDEX FOR 11/2016 S80 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE 

How to replace lightbulb for temp selector switch? S80

hi,
this can be a tricky job to do but here goes....
1, remove pen holder in front of gearshift (lever out each side)
2,remove 2 torx 25 screws at the bottom of the climate control module (called a CCM ,its the big unit with the temp controls on it).
3, heres the tricky part... you pull the bottom of the CCM outwards on a angle untill you can get a couple of fingers under each side of the bottom of the CCM then you need to pull the entire CCM unit outwards while keeping it on a angle.
4,it will be tight to pull out but hopefully it came without breaking the 2 spring metal tabs that held it in place.
5,disconnect the CCM (make sure ign key is off first or this will cause trouble codes to be introduced).
6,you will now need to find the bulbs on the CCM and replace them, this may require some dissasembly of the CCM, the bulbs come as part of a coloured holder which has a straight slot on the back to unscrew half a turn with a small screwdriver.
7,put it all back together.

good luck.

steve.






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New How to replace lightbulb for temp selector switch? [S80]
posted by  someone claiming to be G Squared  on Mon Mar 21 17:35 CST 2005 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.