Volvo AWD S60 Forum

INDEX FOR 10/2025(CURRENT) INDEX FOR 3/2004 S60 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE 

cylinder misfire, rough cold start, baked plug S60 2002

posted by  Rockytop on  Thu Aug 13 06:05 CST 2009
Author: [PROFILE] [EVERY POST] [THREADS] [BEST POSTS] RSS Feed     [IGNORE ALL POSTS]
last visit: Tue May 10 13:59 CST 2011
[RELATED]

Engine burns some oil (no external leaks) - probably half quart every 500 miles(?), w/ no visible smoke from exhaust. Got fault code of P0304, "Cylinder 4 misfire." Pulled the plug and it was the worst looking plug I've EVER seen (genuine volvo) w/ all three prongs 80-90% gone and center electrode 90+% gone. It's possible that these were original -- has 41,000 miles. I got it at about 37k, no service history. I reset CEL, replaced all plugs w/ Bosch Super Plus copper; #4 was clearly the worst. Don't think that it was "placebo effect," but it seemed to run amazingly better, real acceleration for the 1st time.
About 2 days later, same code reappeared.
Car idles rough ONLY w/ cold engine, but doesn't miss as far as I can tell.
Should I switch the coil pack between 4 and another cylinder then get codes re-read? What else should I do if that doesn't help?






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New cylinder misfire, rough cold start, baked plug [S60][2002]
posted by  Rockytop  on Thu Aug 13 06:05 CST 2009 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.