Volvo RWD 200 Forum

INDEX FOR 10/2025(CURRENT) INDEX FOR 5/2003 200 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE 

Rubber Stopper on Differential Leaking Gear Oil 200 1988

posted by  someone claiming to be helloitsgraham on  Mon Jun 27 08:18 CST 2005 [RELATED]

Hi,

I had gear oil leaking from the back plate of rear differential. I have confimed the leak is not coming from the filler nut or any driveline seals, but rather from a rubber boot and wire that's installed just above the filler nut. My neighborrhood mechanic cleaned the area around this rubber boot and sealed it with silicone to stop the leak - so far so good.

I'm looking to know what the rubber boot is for. It has a cable / thick wire running out of it, but I can't find where the cable runs to (the rear stabilizer bar and panhard get in the way). The Chilton manual implied it might be the electronic pickup for the speedometer (but not for this model car), and the mechanic was not sure what it's for. I do notice the speedo needle on the dash sometimes jumps up to 20 or even 40 mph quickly and with no ryhme or reasons (happens even when car is stopped).

This is a 1988 245 with 168,000 miles.






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New Rubber Stopper on Differential Leaking Gear Oil [200][1988]
posted by  someone claiming to be helloitsgraham  on Mon Jun 27 08:18 CST 2005 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.