Volvo RWD 700 Forum

INDEX FOR 10/2025(CURRENT) INDEX FOR 4/2010 700 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE 

Fuel Filter Replacement... Gone Bad HELP! 700

posted by  someone claiming to be Joe on  Sun Apr 13 02:21 CST 2003 [RELATED]

Ok I admit... I shouldn't have taken this on, on my own. I ended up having a friend come and help me finish it up. From what I can tell everything is hooked back up correctly. But the engine is not turning over? I've tried starting 4 times. I get good cranking but no start. Here's how the fuel filter replacement went:

1. Depressurized Fuel System (Started Car, Removed Fuel Pump Fuse, Car Died, Shut off Car.)
2. Disconnect Negative battery terminal.
3. Remove harness holding LH Jetronic Pump and Filter
4. Disconnect both leads to pump. (GND & ORG)
5. Disconnect Banjo on Pump Side (Mistake #1)
6. Disconnect Banjo on Engine Side
7. Replaced Fuel Filter (Placed filter in bracket, reconnected with bolts each having two new copper compression washers.
8. Bolt up harness.
Next Morning
1. Put in fuel pump fuse
2. Reconnect Battery
3. Go to Start.... Nothin except it cranks but won't turnover.

Any Ideas???!?!??!???!??!!!! PLEASE!!! HELP!


Joe Doherty






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New Fuel Filter Replacement... Gone Bad HELP! [700]
posted by  someone claiming to be Joe  on Sun Apr 13 02:21 CST 2003 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.