Volvo RWD 200 Forum

INDEX FOR 10/2025(CURRENT) INDEX FOR 10/2004 200 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE 

Transmission noise or clutch noise? 200

1983 245, 376,000 miles and change. Original B23F and M46.

I had a new clutch put in about 3 years and 15,000 miles ago. The mechanic who did the work is a well respected Volvo specialist who has worked on my car for over 20 years, and he used OE parts (Sachs). The pilot and throw-out bearings were replaced, the flywheel was resurfaced, he replaced the rear main seal and the transmission mount.

About a month ago, the car started making a horrible noise. It sounds like a bearing going south. The pitch increases/decreases with the speed of the transmission. For example, if I accelerated up to 45 mph in 4th gear, then push in the clutch and downshift into 3rd, the whine increases dramatically in pitch and volume, even though the car is coasting (engine rpm at idle). Shift back into 4th, without letting the clutch out, and it quiets down considerably.

There is also a "rushing" sound (like running water) when the car is stationary and the clutch is engaged. If I push the clutch to the floor, the sound stops.

How do I tell the difference between a bad T/O bearing and internal transmission problems?






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New 1 Transmission noise or clutch noise? [200]
posted by  someone claiming to be Dan Connors  on Mon Mar 26 21:19 CST 2018 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.