Volvo RWD 200 Forum

INDEX FOR 10/2025(CURRENT) INDEX FOR 10/2004 200 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE 

Quick repair for 245 tailgate wiring - probably heresy but 200 1992

3 of the 4 wires on my 92 245 tailgate harness were cut through at the hinge. I had no rear wiper or washer. I read through the threads here and the detailed instructions on Swedishbricks.com.

I pulled the headliner back, unhooked the connector, pulled some slack, and worked on making a connection for ~ 1/2 hour. Even if I could make connections, I thought they'd just get recut by the lip.

So I cut the final wire, pulled the harness out inside and pulled the other end through the round access hole in the tailgate. I then soldered and taped each wire, wrapped the cable and fed it through a hole I punched into the headliner. It works fine, it has plenty of slack and flex, it's marginally visible.

I'm sure this isn't a good approach for everyone but it's a robust solution to a problematic wiring area and, sorry, it was an easy function-over-form choice for me.

Note: the 92 has only one wiring harness back there - on the passenger side. One of my earlier cars has one on each side.
--
85-92 240s/ 245s - parts cars & drivers






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New 1 Quick repair for 245 tailgate wiring - probably heresy but [200][1992]
posted by  jon_h  on Sat Feb 23 13:26 CST 2008 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.