Volvo RWD 444-544 Forum

INDEX FOR 10/2025(CURRENT) INDEX FOR 11/2011 444-544 INDEX

[<<]  [>>]


THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD




  REPLY TO THIS MESSAGE    PRINT   SAVE 

544weather strip channel 444-544

Does anyone know of alternate or replacement for the weather strip channel along door bottoms. Mine are rotted off.








  REPLY TO THIS MESSAGE    PRINT   SAVE 

544weather strip channel 444-544

Thanks for the input. This was about what I expected. I may experiment with just gluing the rubber to the doors with perhaps 2 or 3 sheetmetal screws or rivets at strategic places. An alternative might be to find a weather strip with a profile more conducive to gluing into a corner as is done on many other vehicles.








  REPLY TO THIS MESSAGE    PRINT   SAVE 

544weather strip channel 444-544

I was thinking about the same thing. Here is one possibility. It has a wide flange for gluing
Dean

http://www.soffseal.com/store/main.aspx?p=itemdetail&item=E612








  REPLY TO THIS MESSAGE    PRINT   SAVE 

544weather strip channel 444-544

There is another option. This outfit has channel that looks about right but I think they probably want to sell a decent size run of it. How many out there might want some? I can request a quote.
Dean
http://www.johnsonrollforming.com/display.php/display/A2/category/3








  REPLY TO THIS MESSAGE    PRINT   SAVE 

544weather strip channel 444-544

I used some "c" channel pieces from an old door that was damaged. Got them from the sides where they were still good.
Rob








  REPLY TO THIS MESSAGE    PRINT   SAVE 

544weather strip channel 444-544

Hello,

Just about all the rubber is available new including the lower door seals.

FYI, the rubber seals for both opening rear quarter windows just recently became available as well along with the front and rear windshield trim.
--
Eric
Hi Performance Automotive Service (formerly OVO or Old Volvos Only)
Torrance, CA 90502








  REPLY TO THIS MESSAGE    PRINT   SAVE 

544weather strip channel 444-544

Hi Eric: I think the question was referring to the metal "C" channel that the rubber weatherstripping rides in. I have the same problem and havent really been able to find it new. I was thinking about ways to fabricate the missing pieces but not too easy. A local sheet metal shop might be the way to go for straight sections. Might be able to bend it to the curves but not sure.
Dean

Dean V.
61 544 & 69 1800








  REPLY TO THIS MESSAGE    PRINT   SAVE 

544weather strip channel 444-544

Hello,

I think you are right.

Volvo used to sell the "C" channel separately, but it is no longer available.

Back in the early 1990's, we did a partial restoration on a 544 and we ran into the same problem.

IIRC, the "C" channel was still available back then, but it was cheaper to buy a used non-running 544 with good doors than the labor quote for removing, preparing, bending(the "C" channel was supplied with no bends) and installing the channel to the doors.
--
Eric
Hi Performance Automotive Service (formerly OVO or Old Volvos Only)
Torrance, CA 90502







<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.