Volvo RWD 200 Forum

INDEX FOR 10/2025(CURRENT) INDEX FOR 12/2004 200 INDEX

[<<]  [>>]


THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD




  REPLY TO THIS MESSAGE    PRINT   SAVE 

Drivers Door Panel 200 1993

Is here anywhere with instructions on how to remove the drivers side door panel to work on the window?

Thanks
Frank








  •   REPLY TO THIS MESSAGE    PRINT   SAVE 

    Drivers Door Panel 200 1993

    Unscrew the lock knob
    Pull the trim ring off the inside door handle
    Remove 3 torx scews on arm rest
    twist the rear of the arm rest up and slide out the power window switches and then unplug
    Keep turning up the rear of the armrest until the front end releases
    Remove the 3 plastic clips on the pocket by tuning with a dime
    Push up on the pocket to release the top, then remove the top 2 screws.
    The speaker will come off with the door panel, so no need to remove

    Carefully pop all of the clips on the bottom and sides of the door panel. I use a thin paint scraper inserted between the panel and the door. Try to pry as close to the clips as possible, because it is very easy to rip the clips out of the cardboard. The bottom of clips will likely rip out because the door panel is often water damaged here. But this is not a big deal since the pocket holds the bottom on too.

    Once the bottom and sides are unclipped push the door panel up to release.







<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.