Volvo AWD S80 Forum

INDEX FOR 1/2026(CURRENT) INDEX FOR 12/2001 S80 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE 

Quick! Help on brakes again! S80

posted by  someone claiming to be n0v8or on  Sun May 22 01:57 CST 2005 [RELATED]

I see I took your earlier message too literally.
Try this test:
With the engine running, pump as necessary to obtain a firm pedal. Now hold that pressure on the pedal for about 60 seconds, and see if the pedal slowly moves toward the floor. If it does, there is an internal leak (assuming the reservoir chamber stays full). If not, there may be air in the system.

Some questions:
As you pump it, does the pedal feel like there ia an inflated baloon between it and your foot?
How did you retract the caliper piston to install the new pads?
Did you remove the caliper or rotor?
Approximately how much friction material was left on the old pads; more or less than 1/8"?






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New Quick! Help on brakes again! [S80]
posted by  pharmman2002  on Sat May 21 06:37 CST 2005 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.