Volvo AWD 850 Forum

INDEX FOR 10/2025(CURRENT) INDEX FOR 6/2012 850 INDEX

[<<]  [>>]


THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD




  REPLY TO THIS MESSAGE    PRINT   SAVE 

Loss of engine smoothness, ECU problem? 850 1995

My 850 GLT 2.5L 10V Manual has developed a fault when applying power or decelerating. It is especially noticable at low speeds. When depressing the accelerator to go faster or taking your foot off to decelerate the car jerks (single jerk)as it takes up speed or slows down. The fault also makes gear change unpleasant and difficult to do smoothly. It's as if the engine revs are incorrect for the speed being travelled. The car sometimes struggles to maintain constant revs at slow speeds (20-30mph) The engine also sometimes over-runs after turning it off .

I've had the distributor cap, rotor arm, HT leads and coil changed and have had the throttle control unit cleaned out, all to no avail.

I was begining to put it down to wear and tear and old age but strangely, for two days recently, the car suddenly drove perfectly and was back to its old self and as smooth as silk but the fault returned on the third day. Is it a ECU problem? No fault codes show up.








  •   REPLY TO THIS MESSAGE    PRINT   SAVE 

    Loss of engine smoothness, ECU problem? 850 1995

    Was your battery disconnected during any of those mech. ops? If so, this causes a relearn in the computer, a sort of reset. It has to build memory of driving conditions etc. after the battery is disconnected. That's probably why it started to drive fine again after a little while.








    •   REPLY TO THIS MESSAGE    PRINT   SAVE 

      Loss of engine smoothness, ECU problem? 850 1995

      Before all this started the car broke down. It wouldn't start and had to be jump started using another vehicles battery. Fault codes showed up when restarted but they made no sense. Since then I've had the problems as reported. I must admit the car has been running better recently but still over-runs now and again.








  •   REPLY TO THIS MESSAGE    PRINT   SAVE 

    Loss of engine smoothness, ECU problem? 850 1995

    My guess is it's a fuel problem - check your fuel pressure at the rail - maybe failing fuel pump, relay, fuel pressure regulator, or maybe dirty injectors too (especially if you are experiencing dieseling - overrun).








  •   REPLY TO THIS MESSAGE    PRINT   SAVE 

    Loss of engine smoothness, ECU problem? 850 1995

    have you changed the air filter and cleaned the air meter from that?
    (Do you use the standard air filter or oiled ones?)








    •   REPLY TO THIS MESSAGE    PRINT   SAVE 

      Loss of engine smoothness, ECU problem? 850 1995

      The air filter has been changed but I'll check the meter.

      Please excuse my ignorance but please explain the difference between oiled filters and standard ones. Thanks

      Harvey850








      •   REPLY TO THIS MESSAGE    PRINT   SAVE 

        Loss of engine smoothness, ECU problem? 850 1995

        The standard Volvo air filter is dry, though you can buy 'performance' filters which have a light coating of oil. If over-oiled the oil can coat the air sensors (in the tubing just off the filter) and cause it to either give false reading or fail.







<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.