Volvo AWD 850 Forum

INDEX FOR 10/2025(CURRENT) INDEX FOR 1/2004 850 INDEX

[<<]  [>>]


THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD




  REPLY TO THIS MESSAGE Replies to this message will be emailed.    PRINT   SAVE 

HELP - Overheating 850 94

posted by  someone claiming to be Bob on  Tue Apr 10 14:57 CST 2001 [RELATED]

My 94 850 started over heating on th expressway tonight.

It seemed that the small plastic overflow tank (above the passenger side front wheel) was spewing steam abd water/coolant all over the place. There are no obvious cracks, or breaks anywhere, car still drove great, just a lot of smoke/steam from under the hood. It has been towed to a repair shop, but I want to know what I am in for.

Any help will be appreciated.

Thanks,

Bob







  •   REPLY TO THIS MESSAGE Replies to this message will be emailed.    PRINT   SAVE 

    Re: HELP - Overheating 850 94

    posted by  someone claiming to be Wayne on  Thu Apr 12 03:23 CST 2001 [RELATED]

    What about the water pump?







    •   REPLY TO THIS MESSAGE Replies to this message will be emailed.    PRINT   SAVE 

      Re: HELP - Overheating 850 94

      posted by  someone claiming to be Bob on  Thu Apr 12 12:44 CST 2001 [RELATED]

      Thanks to all that responded - it turned out to be the radiator itself.

      Bob







  •   REPLY TO THIS MESSAGE Replies to this message will be emailed.    PRINT   SAVE 

    Re: HELP - Overheating 850 94

    posted by  someone claiming to be Rich K. Fairfax, VA on  Wed Apr 11 13:54 CST 2001 [RELATED]

    The newer Blue/green cap is a good move, the thermostat could of stuck shut, so that could be a part needed, and a look at the relay that works the fan speeds might show that its not turning on the fan when it should.







  •   REPLY TO THIS MESSAGE Replies to this message will be emailed.    PRINT   SAVE 

    Re: HELP - Overheating 850 94

    posted by  someone claiming to be Ray Niblett on  Wed Apr 11 05:54 CST 2001 [RELATED]

    The gray colored coolant overflow caps are known to fail. I believe

    newer ones are blue. Also, a few people have reported thermostat

    failures seem to start at around 70K miles.







  •   REPLY TO THIS MESSAGE Replies to this message will be emailed.    PRINT   SAVE 

    Re: HELP - Overheating 850 94

    posted by  someone claiming to be SCFrost on  Wed Apr 11 00:23 CST 2001 [RELATED]

    It is more than likely the thermostat. Not a big deal unless you boiled it dry.

    94 850 Turbo, IPD ECU, 89K miles






<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.