Volvo AWD Forum

INDEX FOR 10/2025(CURRENT) INDEX FOR 9/2020

[<<]  [>>]


THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD




  REPLY TO THIS MESSAGE    PRINT   SAVE 

removal of 850 Heater Control Unit

posted by  someone claiming to be MoncureWW on  Sat Jan 16 17:45 CST 2010 [RELATED]

Does anyone have any tips on removing the 850 heater control unit? I got the stereo down pat, I'm just stuck on the heater control unit. S70's you just pop 'em from the back but on the 850 I'm stumped.








  REPLY TO THIS MESSAGE Replies to this message will be emailed.    PRINT   SAVE 

removal of 850 Heater Control Unit

posted by  KlausC on  Sun Jan 17 04:42 CST 2010
Author: [PROFILE] [EVERY POST] [THREADS] [BEST POSTS] RSS Feed     [IGNORE ALL POSTS]
last visit: Fri Oct 24 10:15 CST 2014
[RELATED]

Same as the S70, just pull! Keep one hand on the front of the unit, it tends to come out really fast.

Klaus
--
Proud owner of a 220S. If I had more room, I would have more Volvos.








  REPLY TO THIS MESSAGE Replies to this message will be emailed.    PRINT   SAVE 

Removal of ENTIRE 850 Heater Control Unit 850 1997

posted by  New2Volvo2 on  Thu Oct 27 06:09 CST 2011
Author: [PROFILE] [EVERY POST] [THREADS] [BEST POSTS] RSS Feed     [IGNORE ALL POSTS]
last visit: Mon Aug 4 12:32 CST 2014
[RELATED]

The stem on the driver side heater control unit no longer turns (I had been adjusting it with a pair of pliers) and I am likely going to need to replace the whole unit -- not just the front panel that the knobs attach to. I went to the junkyard yesterday and found a unit (which looked identical to the one I have) in a 95 donor, and was able to remove the outer plate, however the unit that the stem is connected to is of course behind that, and there are a few springclips (from what I could tell in the dusklight) and maybe a hose or two connected to that part of the unit. It was a bear just trying to move it around inside of the dash, even with the radio taken out. Anyone have any tips on removal of the ENTIRE heater control unit?







<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.