Volvo AWD 850 Forum

INDEX FOR 10/2025(CURRENT) INDEX FOR 5/2013 850 INDEX

[<<]  [>>]


THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD




  REPLY TO THIS MESSAGE    PRINT   SAVE 

sunroof problems 850 1993

posted by  someone claiming to be ipgeepja on  Sat Jul 15 10:25 CST 2006 [RELATED]

1993 850 sunroof won`t close all the way?








  REPLY TO THIS MESSAGE    PRINT   SAVE 

sunroof problems 850 1993

posted by  someone claiming to be ronjon on  Fri Aug 4 15:28 CST 2006 [RELATED]

I sealed mine due to broken guide rails problem.

Remove plastic guards on each side from the inside to access the sunroof mounting screws. Removed all 3 screws on each side. Remove sunroof from outside. Look for rail jam and remove any broken rail parts to free up the paths. Position rails as if the roof is in close position. Gently put the sunroof back on from the outside to check any blockage. If you want to seal the roof permanently, use pure silicone glue around the rubber seal. Gently put the sunroof back on and screw it from the inside. Make sure that the sunroof is leveled with the roof. Make sure to disconnect the motor at the light location after sealing the sunroof.

Or you may find used rails to replace the old one.

Ronjon
'93 859
167k miles, original transmission, no electrical problem, regular maintenance








  REPLY TO THIS MESSAGE    PRINT   SAVE 

sunroof problems 850 1993

posted by  someone claiming to be ronjon on  Fri Aug 4 15:18 CST 2006 [RELATED]

Did you get it fixed?







<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.