Quantcast
RWD - Headlamps, halogens

Volvo RWD 120-130 Forum

INDEX FOR 6/2019(CURRENT) INDEX FOR 9/2003 120-130 INDEX [<<]  [>>]

 VIEW    REPLY TO THIS MESSAGE Replies to this message will be emailed.    PRINT   SAVE   A    A 

Headlamps, halogens 120-130

Kwas - simply trying to provide the OP with another resource he could draw on to make his choice.

I’ve been performing this “upgrade” on cars of mine for (edit - I'm older than I thought....) 30 years. For me, it started with a simple measurement - put the black lead of your DVM on the location where the headlight bulbs are grounded and the red lead on the hot side of the light bulb - check low beams and high beams as there is additional wiring/switching (V loss) with the high beams. Car warmed up and hold the rpm up a bit. Now check voltage at the alt output at same rpm. If you have more than a volt or two difference, you’re losing significant lumens of lighting. Whether it’s in wire length/gauge, connections or switches only matters if you’re willing to replace the offending bits with upgrades. In my experience, every car has significant voltage drops even when new - primarily because of long wire runs and minimal gauge size. Even my wife’s 2016 sees over a volt drop - and I’d bet money those lights are triggered via control module/CAN system. And if you wanna upgrade to more powerful bulbs, upgrades to the system are usually necessary - many popped fuses on E30 BMW trying to run 100W bulbs through factory wiring. In fact, it was that experience that caused me to investigate the V-drop in the first place.

I upgraded the Volvo in an afternoon using spare relays I’d collected over the years. Keep grounds and wiring large gauge and as short as possible. My DVM currently measures 0.00V difference between alt output and the bulb hotsides. I’m seeing a full 14.2-14.6V at the bulb. Hella euro lights with 55W on the low beam and 100W on the high. No worry about burning up fuses or factory wiring/switches. And I can fry eggs at 50’.

Pull out your DVM. I’d lay odds on a perfectly functioning (clean connections) 50 year old system you’ll see at least a 2V drop....lumens left on the table.

Appears you and I have differing opinions on this. I’m good with that.


--
82 242-6.2L; '17 Mazda3; '16 Crosstrek






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New 1 Headlamps, halogens [120-130]
posted by  longhorizon  on Sun May 5 14:21 CST 2019 >

Cut and paste link:

<< < > >>


Users marked in green are currently online.

©Jarrod Stenberg 1997-2016. All material except where indicated.


Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.

All participants agree to these terms.
Powered by Denizen - Custom Software for Enthusiasts