Quantcast
RWD - re: 87 245 auto - maintenance record

Volvo RWD 200 Forum

INDEX FOR 12/2018(CURRENT) INDEX FOR 9/2012 200 INDEX [<<]  [>>]

 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE   A    A 

re: 87 245 auto - maintenance record 200 1987

Hi All,

It's my swedish baklava's maintenance record. I thought some of you might be interested to know. Thank you all for your help so far. Thank you as always.

--

2-27-2011 (purchase date)
136,172 miles
fixed heater fan, replaced trunk door strut shock, replaced front windshield.

3-7-2011
136,256 miles
MD inspection; replaced thermostat, antifreeze, replaced engine oil, filter, front left and right ball joint, replaced head bulb

4-22-2011
140,056 miles
replaced engine oil, filter, drain/fill trans fluid, replaced diff gear fluid, installed IPD flame trap relocation kit by mechanic.

4-27-2011
Miles?
Air box was filled with empty nut shells. Cleaned MAF sensor. Improved gas mileage to 27mpg.

5-25-2011
143,854 miles
passenger side strut mount, water temp sensor and compensation board by mechanic

6-11-2011
144,964 miles
replaced engine oil, filter, flushed power steering fluid

8-12-2011
150,109 miles
replaced head gasket, water pump, timing belt, front crankshaft seal, new radiator, antifreeze, engine oil, filter.

Rebuilt the both seats. took off heated elements.

8-28-2011
passed MD smog inspection

8-27-2011
four new all season tires

10-9-2011
155,110 miles
replaced engine oil, filter.

11-26-2011
159,300 miles
placed wheelskins, replaced engine oil, oil filter, oil plug, fuel filter, air filter, cleaned MAF. replaced trans fluid.

12-2011
Installed trans shifter bushing, need one more.

12-19-2011
four used Nokian snow tires with painted black 14" steel wheels

1/8/2012
163,000 miles
replaced transmission mount & passenger side motor mount & oil/filter change.

1/14/2012
secure radiator plug zip tie through radiator fins temp gauge back to rock steady


3/30/2012
166,640 miles
replaced new brake master cylinder, calipers, brake hose/lines. bled twice. placed new alternator regulator. fixed loose wiper motor magnet, glue it back on. fixed loose ground cable for rear license plate light.

4/21/2012
169,369 miles
Installed IPD in tank fuel pump & relay. Old fuel pump ok but the hose was cracked. Noisy New fuel pump???

4/28/2012
169,900 miles
engine oil, filter

5/14/2012
171,500 miles
cleaned throttle body, cleaned coolant temp sensor connector, fixed loose engine oil sensor wire

5/15/2012
Installed license plate light assembly

5/19/2012
172,000 miles
replaced air filter and air thermostat
replaced rear left tail light assembly

5/29/2012
173,040 miles
replaced rear trailing bushing

6/2/2012
internal water leak
found the source

6/16/2012
175,109 miles
replaced engine oil & oil filter

6/19/2012
175,300 miles
reinforced supply fuel tube; didn't help much with noise

6/25/2012
175,900 miles
install fuel line holder, clean idle air control valve; smoother starting, resting idling.
vaccum rocker panels for dead leaves.

7/15/2012
strange rattling noise from the muffler

7/21/2012
178,800 miles
new ignition coil; advanced auto parts
patched up driver & passenger water drainage hole with clear caulk

7/29/2012
179,777 miles
engine oil & filter, transmission fluid, driver side engine mount
engine finally idle smooth at all speed

7/30/2012
179,777 miles
exhaust system; cat back kit from NAPA

8/5/2012
180,769 miles
drain and fill prestone coolant.

8/25/2012
183,157 miles
replaced accessory bushing, AC and power steering belts.

9/3/2012
184,003 miles
placed IPD overdrive bypass kit

9/3/2012
184,010 miles
clean rocker panel, vacuum, rinse with water, prep and apply POR15
plug windshield rubber grommet

9/16/2012
185,325 miles
oil change, new spark plugs

10/14/2012
188,530 miles
radiator hoses & coolant

10/31/2012
188,530 miles
timing belt, harmonic balancer, alternator v belt, cap/rotor & rear shocks

11/11/2012
189,200 miles
changed idle control valve
no more hiccup as the engine rpm comes to idle, smooth take off from stop

11/13/2012
189,400 miles
timing belt tensioner adjustment

11/17/2012
189,968 miles
engine oil and filter change
resonator rubber clamp fell out

12/23/2012
rusted spots patched up

1/12/2013
195,351 miles
oil, oil filter changed
oil leak from oil filter or seals or plate gasket

1/20/2013
196,600 miles
brake fluid flush
checked front brake 50% remain life
hissing sound from under the dash

3/3/2013
200,098 miles
oil & filter change
flametrap checked, clean
hissing sound is gone

4/7/2013
203,683 miles
trans fluid & differential fluid

4/22/2013
203,683 miles
butyl sealant for windshield, new timing belt, tensioner, oil seal & seal plate gasket

5/4/2013
203,683 miles
washed rocker panels, all door frame area, washed wheel wells, rust proofing, watch top frame in the engine bay,inserted foam tape on transmission lines. full size spare tire in the trunk

5/25/2013, 6/9/2013
205,897 miles
strut, bumper stopper, strut cover, ball joint & regrease inner tie rod

6/13/2013
205,897 miles
rear main seal by mechanic

6/15/2013
205,904 miles
tie rod end
engine oil & oil filter
checked oil breather

6/16/2013
205,904 miles
wheel alignment

6/29/2013
207,000 miles
replace oil plug washer, new oil,
metal filler on welded panel areas

9/16/2013
210,910 miles
heater core, new coolant, used battery, cleaned & wrapped battery terminal + coil wire connector

9/24/2013
211,540 miles
oil pressure sender

9/30/2013
212,035 miles
air filter, fuel filter & fuel sock
replaced oil separator
clean MAF and throttle body
brake pads
repack wheel bearing

10/19/2013
214,131 miles
oil & oil filter
checked voltage regulator/ 8-9mm left
cleaned + greased terminals
refoam tranny lines
POR15 underbody

11/10/2013
215,334 miles
new cam shaft seal
greased all u joints + center support bearing

11/30/2013
217,400 miles
retighten the valve cover nuts

12/21/2013
219,228 miles
oil and oil filter change
retighten the alternator belt
new CAT back exhaust pipe from IPD/Starler
NAPA exhaust lasted 39,451 miles (bad diagnostic, bad CAT)

1/8/2014
220,100 miles
new radiator

2/2/2014
221,414 miles
new center support bearing, new support rubber, spring, seat, new tail bushing shaft seal + greased U-joints

2/17/2014
221,414 miles
fuel pressure regulator, clean MAF, fuel injector cleaner + Italian tune up

3/2/2014
223,000 miles
high idle @1200, checked for vacuum leak, cleaned throttle body.

3/23/2014
224,750 miles
oil & oil filter change
air filter
fan clutch
rear rotors & glued e brake pad on rear passenger side
trans fluid/drain & refill 2 quarts

4/3/2014
225,500 miles
leaky transmission cooling line; patched up with metal putty

4/13/2014 + 4/20/2014
227,911 miles
spark plugs, cap, rotor and wires
rust on rear floor pan & rear wheel weld section/driver side
tightened exhaust clamp
redo trans fluid line

4/28/2014
228.000 miles
fixed hatch rust

4/19/2014
229,809 miles
oil, oil filter and brake fluid flush

5/25/2014
230,100 miles
passenger/rear caliper brake leak
ordered a caliper from Autozone

5/31/2014
231,001 miles
placed new caliper

7/14/2014
234,851 miles
oil change
replaced transmission cooling line
rear cam plug

8/6/2014
leaky front passenger braker bleed screw + missing cap

8/25/2014
239,000 miles
new water pump

8/31/2014
239,811 miles
oil change + voltage regulator

9/19/2014
241,748 miles
rear brake pads + touch up rust spots + strapped loose CAT shield

9/29/2014
242,788 miles
Used Uro mounts from 93 240

10/26/2014
245,321 miles
heater hoses, thermostat, v belt, timing belt, oil seals, coolant hoses, water pump gasket, air filter, air thermostat, engine oil

11/4/2014
redo crankshaft seal, water pump gasket + heater core hoses
swapped emergency switch + wiper relay

11/13/2014
246,362 miles
power steering fluid changed using a turkey baster

1/2/2015
249,828 miles
oil & filter change
fire wall rust proofing

3/1/2015
254,878 miles
oil & filter change
transmission fluid; drain & fill

2015
3/14/2015
255,000 miles
rear wheel bearing

4/4/2015
257,459 miles
center support bearing

4/26/2015
260,000 miles
tail gate strut
4th exhaust pipe bolts tightened
oil & oil filter
spark plugs, air filter, cap, rotor & coil

5/24/2015
262,240 miles
tail gate hatch ground wire fix
touch up rust spots
inject grease on tie rods
windshield wiper foot rubber mount

6/11/2015
264,309 miles
fuel pump relay; resoldered
main fuel pump, hose & fuel filter


6/27/2015
265,409 miles
oil & oil filter


7/5/2015
266,126 miles
rear passenger driving light; replaced brake light bulb socket holder
greased U joints & ball joints
fixed oil pressure line


8/9/2015
269,741 miles
oil & oil filter
cleaned negative battery terminal

10/12/2015
275,098 miles
oil& oli filter
muffler mount
clean connector

11/13/2015
277,772 miles
coolant replaced

11/28/2015
278,940 miles
brake fluid, wheel bearing repack grease, fix rust, polished lens, interior vacuum air leak & brake air leak

12/9/2015
280,003 miles
oil + oil filter replaced
1/8" diameter metal particles

12/12/2015
280,500 miles
power steering pump, rust proofing, air filter & cleaned throttle body

12/25/2015
281,925 miles
replaced bumper & took out the loose CAT shield

1/18/2016
284,000 miles
#1 bad wire plug & cleaned throttle body

1/29/2016
284,937 miles
oil & filter change

2/19/2016
286,879 miles
brake pad worn unevenly, stuck caliper piston

2/20/2016
286,943 miles
trans fluid change

3/25/2015
289,849 miles
oil change, spark plug, wire, cap & rotor, passenger rear caliper, rear bumper rust, passenger wheel bearing rubber seal, torque/pad rod bushing

3/30/2015
290,400 miles
rear shocks

4/17/2016
292,099 miles
air filter, strut, strut mounts, ball joint, tie rods, timing belt, belt tensioner and seals.

4/21/2016
292,500 miles
new cam seal, new coolant, water pump and radiator

5/1/2016
294,000 miles
in take fuel pump filter

5/19/2016
295,218 miles
oil change

5/29/2016
296,111 miles
front solid rotors, brake pads, CAT, crank seal, differential fluid & passenger side mount
8mm voltage regulator, check grease cap, coolant cap & clean oil separator

6/11/2016
297,335 miles
front vented rotors, front left caliper & bleed

7/3/2016
299,353 miles
oil change, main fuel filter change

7/11/2016
300,100 miles
Autozone alternator & used alternator brush

9/3/2016
305,050 miles
oil change

10/1/2016
307,100 miles
air filter & sway bar end links

11/11/2016
309,937 miles
oil change, trans fluid change, tightened driver front control arm bushing nut & fuel pick-up tube loose

1/5/2017
314,767 miles
oil change

1/20/2017
316,052 miles
rear trailing arm bushing & grease u-joints & check fuel line

4/30/2017
318,445 miles
replaced front brake pads

5/20/2017
318,806 miles
accessory bushing/alternator (3/8" brush length), used alternator brush, brake flush, & rust treatment

6/26/2017
intank fuel pump cover rust treatment

7/2/2017
319,641 miles
oil change

8/7/2017
320,212 miles
front brake pads

8/16/2017
320,500 miles
clean idle control valve, flame trap, oil seperator, throttle body, & passenger rear brake pads

10/15/2017
321,500 miles
new tires, coolant replaced, air filter, repack wheel bearing

10/29/2017
322,220 miles
POR15 rust, rear light bulb issue, torque rod bolt replacement

11/26/2017
322,500 miles
hood lock, front wheel alignment

12/3/2017
322,840 miles
plug, cap, rotor and added 1/4 quart of trans fluid

12/24/2017
323,200 miles
rust treatment, acc belt adjustment, hose clamp, & used coil (24,000 miles)
Advanced Auto coil life span (120,200 miles)

12/26/2017
323,600 miles
delam e brakes/driver side

1/31/208
324,000 miles
rear calipers & alignment

2/10/2018
324,131 miles
oil change, drain & fill power steering, passenger engine mount, rust spot by rear driver side wheel area, new battery, & grease hinge

4/28/2018
325,573 miles
timing belt tensioner

 





[about brickboard ads]

THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New 1 re: 87 245 auto - maintenance record [200][1987]
posted by  Swedish Baklava  on Sun May 6 10:04 CST 2018 >

[about brickboard ads]

Cut and paste link:

<< < > >>


Users marked in green are currently online.

©Jarrod Stenberg 1997-2016. All material except where indicated.


Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.

All participants agree to these terms.
Powered by Denizen - Custom Software for Enthusiasts